一种基于ACOT的Buck型开关电源设计

doi:10.16257/j.cnki.1681-1070.2023.0151

电子与封装 ›› 2023, Vol. 23 ›› Issue (11): 110303 . doi: 10.16257/j.cnki.1681-1070.2023.0151

一种基于ACOT的Buck型开关电源设计

谢凌寒¹,孙祎轩²,周颖¹,荣悦²

1.无锡力芯微电子股份有限公司，江苏无锡 214028；2.东南大学集成电路学院，南京 210096

收稿日期:2023-06-19 出版日期:2023-11-28 发布日期:2023-11-28
作者简介:谢凌寒（1981—），男，江苏无锡人，硕士，工程师，主要研究方向为模拟集成电路设计。

Design of Buck Switching Power Supply Based on ACOT

XIE Linghan¹, SUN Yixuan², ZHOU Yin¹, RONG Yue²

1. Wuxi EtekMicro-Electronic Co., Ltd.,Wuxi 214028, China；2. School of Integrated Circuits, Southeast University, Nanjing 210096,China

Received:2023-06-19 Online:2023-11-28 Published:2023-11-28

摘要/Abstract

摘要： 基于自适应恒定导通时间（ACOT）控制方式，设计了一种恒频效果良好的降压型DC-DC转换器。该转换器采用V²COT架构，兼具输出精度高和瞬态响应速度快的特点。采用一种改进的自适应导通时间控制方式，降低了负载电流对开关频率的影响，使转换器在连续导通模式（CCM）下具有良好的开关频率稳定性。基于东部高科0.15 μm BCD工艺完成流片，芯片输入电压为4.5~17 V，输出电压为0.76~7 V，最大负载电流为3 A，开关频率为1 MHz。测试结果表明，在CCM模式下，开关频率随输入电压变化率为2.67 kHz/V，随负载电流变化率为2.95 kHz/A，峰值效率达96.43%，输出电压纹波为8. 2mV，负载调整率为0.93%，负载瞬态响应时间小于20μs。

关键词: 自适应导通时间, 恒定开关频率, 降压型DC-DC转换器, 低输出电压纹波

Abstract: Based on adaptive constant on time (ACOT) control mode, a step-down DC-DC converter with good constant-frequency effect is designed. The converter adopts V²COT architecture, and has the characteristics of high output accuracy and fast transient response. An improved adaptive on time control mode is adopted to reduce the influence of load current on switching frequency so that the converter has good switching frequency stability under continuous conduction mode (CCM).Based on 0.15 μm BCD process of DB HiTek, the tape-out is carried out. The input voltage is 4.5-17 V, the output voltage is 0.76-7 V, the maximum load current is 3A, and the switching frequency is 1 MHz. The test results show that the switching frequency varies with the input voltage at a rate of 2.67 kHz/V and with the load current at a rate of 2.95 kHz/A under CCM, the peak efficiency is 96.43%, the output voltage ripple is 8.2 mV, the load adjustment rate is 0.93%, and the load transient response time is less than 20 μs.

Key words: adaptive on time, constant switching frequency, step-down DC-DC converter, low output voltage ripple

中图分类号:

TN432

谢凌寒,孙祎轩,周颖,荣悦. 一种基于ACOT的Buck型开关电源设计[J]. 电子与封装, 2023, 23(11): 110303 .

XIE Linghan, SUN Yixuan, ZHOU Yin, RONG Yue. Design of Buck Switching Power Supply Based on ACOT[J]. Electronics & Packaging, 2023, 23(11): 110303 .

参考文献

[1] CHEN W C, CHEN H C, CHIEN M W, et al. Pseudo-constant switching frequency in on-time controlled buck converter with predicting correction techniques[J]. IEEE Transactions on Power Electronics, 2016, 31(5): 3650-3662.
[2] WANG B, CHEN D, CHEN C J, et al. Stability prediction of integrated-circuit based constant on-time controlled buck converters[J]. IEEE Transactions on Power Electronics, 2021, 36(6): 6838-6849.
[3] LIN H C, FUNG B C, CHANG T Y. A current mode adaptive on-time control scheme for fast transient DC-DC converters[C]// 2008 IEEE International Symposium on Circuits and Systems (ISCAS), Seattle, 2008: 2602-2605.
[4] SUN Q, MA Y Z, YE Z J, et al. A pseudo-constant frequency constant on-time buck converter with internal current ripple injection and output DC offset cancellation[J]. IEEE Access, 2019, 7: 175443-175453.
[5] KONG L, CHEN D, HSIAO S F, et al. A novel adaptive-ramp ripple-based constant on-time buck converter for stability and transient optimization in wide operation range[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2018, 6(3): 1314-1324.
[6] LI J, LEE F C. Modeling of V2 current-mode control[C]// 2009Twenty-FourthAnnualIEEEAppliedPowerElectronicsConferenceandExposition, Washington, 2009: 298-304.
[7] 夏剑平, 王彬, 黄堃, 等. COT模式下内置纹波补偿技术的Buck变换器[J]. 电子与封装, 2019, 19(1): 13-17.
[8] YANG W H, HUANG C J, HUANG H H, et al. A constant-on-time control DC-DC buck converter with the pseudowavetracking technique for regulation accuracy and load transient enhancement[J]. IEEE Transactions on Power Electronics, 2018, 33(7): 6187-6198.
[9] JIANG C R, CHAI C C, HAN C X, et al. A high performance adaptive on-time controlled valley-current-mode DC-DC buck converter[J]. Journal of Semiconductors, 2020, 41(6): 062402.
[10] TSAI C H, LIN S M, HUANG C S. A fast-transient quasi-V2switching buck regulator using AOT control with a load current correction (LCC) technique[J]. IEEE Transactions on Power Electronics, 2013, 28(8): 3949-3957.
[11] ZHAO J X, YE Q, LAI X Q. A frequency stable on-time control buck converter with reference and frequency compensation technique using low ESR output capacitor[J]. IEEE Transactions on Industrial Electronics, 2022, 69(4): 3536-3545.

[1]	徐海铭, 汪敏. 30 V SGT N-Channel MOSFET总剂量效应研究[J]. 电子与封装, 2023, 23(11): 110402-.
[2]	张彤;刘树强;何亮;成绍恒;李柳暗;敖金平. GaN基互补型逻辑电路的研究进展及挑战^*[J]. 电子与封装, 2023, 23(1): 10101-.
[3]	牟草源;李根壮;谢文良;王启亮;吕宪义;李柳暗;邹广田. 微波等离子体化学气相沉积法制备大尺寸单晶金刚石的研究进展^*[J]. 电子与封装, 2023, 23(1): 10104-.
[4]	刘保军;杨晓阔;陈名华. 4H-SiC基FinFET器件的单粒子瞬态效应研究^*[J]. 电子与封装, 2022, 22(11): 110401-.
[5]	赵越超, 张理振, 刘海涛. 应用于14 bit逐次逼近型ADC的前台数字校准算法^*[J]. 电子与封装, 2022, 22(10): 100302-.
[6]	阳佳丽, 赵新, 高博, 张析, 龚敏. 基于双极型晶体管的温度传感器[J]. 电子与封装, 2022, 22(9): 90301-.
[7]	戴星明;刘颖异;唐旭升. 电流舵数模转换器的静态误差分析与建模^*[J]. 电子与封装, 2022, 22(8): 80303-.
[8]	赵建欣, 廖春连. 一种超宽带频率综合器电路的设计与实现[J]. 电子与封装, 2022, 22(7): 70305-.
[9]	赵晓松;顾祥;张庆东;吴建伟;洪根深. 全耗尽绝缘层上硅技术及生态环境简介[J]. 电子与封装, 2022, 22(6): 60501-.
[10]	邵杰;唐路. 应用于高精度模数转换器的乘法数模单元模块研究^*[J]. 电子与封装, 2022, 22(4): 40305-.
[11]	朱晓杰;王栋. LED驱动电路中的过零检测技术[J]. 电子与封装, 2022, 22(3): 30303-.
[12]	张阳;王党会;郑俊娜. MOSFET器件质量与可靠性的互补表征体系研究[J]. 电子与封装, 2021, 21(11): 110405-.
[13]	张伟, 祝名, 李培蕾, 屈若媛, 姜贸公. 微系统发展趋势及宇航应用面临的技术挑战[J]. 电子与封装, 2021, 21(10): 100101-.
[14]	邵颖飞,鲁征浩. 基于皮尔斯振荡器的8 MHz晶振电路设计[J]. 电子与封装, 2021, 21(2): 20303-.
[15]	马文超. BUCK 电路外围器件参数选型分析[J]. 电子与封装, 2019, 19(12): 28-31.

中国半导体行业协会封装分会会刊

中国电子学会电子制造与封装技术分会会刊

一种基于ACOT的Buck型开关电源设计

Design of Buck Switching Power Supply Based on ACOT

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价