一种基于CS-MCT串联的脉冲放电电路设计与实现

doi:10.16257/j.cnki.1681-1070.2020.0706

电子与封装 ›› 2020, Vol. 20 ›› Issue (7): 070305 . doi: 10.16257/j.cnki.1681-1070.2020.0706

一种基于CS-MCT串联的脉冲放电电路设计与实现

张兴强，陈楠，陈万军

电子科技大学电子薄膜与集成器件国家重点实验室，成都　610054

接受日期:2020-03-10 发布日期:2020-03-23
作者简介:张兴强（1992—），男，四川康定人，电子科技大学硕士研究生，研究方向为新型功率半导体器件与集成电路和系统。

Design and Implementation of a Pulse Discharge Circuit Based on CS-MCT Series

ZHANG Xinqiang, CHEN Nan, CHEN Wanjun

State Key Laboratory of Electronic Thin Film and Integrated Device, UESTC, Chengdu 610054, China

Accepted:2020-03-10 Published:2020-03-23

摘要/Abstract

摘要： 一种阴极短接的MOS栅控晶闸管（CS-MCT）以其极低的导通压降，简单的栅极驱动电路被广泛应用于脉冲功率领域。但由于系统对高耐压开关器件的需求不断提高，单个器件的耐压已经无法满足，所以器件串联来提升耐压是一种快速且经济的解决方案。通过对栅极等效电路进行分析，得出了在不影响器件正常导通的情况下适量的增大栅极电阻可以提高电路的可靠性。驱动端使用变压器隔离原理，可以有效的进行高压隔离并且提高栅极信号同步性。通过对串联电路动态均压进行仿真，得出在每个器件并联RCD吸收电路可以消除由于器件寄生参数不一致而导致的延迟开启的器件两端的尖峰电压。最后对串联电路进行了测试分析，得出了一种电路简单、可靠性高、均压性好、高峰值电流的串联电路。

关键词: MOS栅控晶闸管, 脉冲放电, 串联电路, 动态均压, 静态均压

Abstract: A cathode-shorted thyristor (CS-MCT) is widely used in the field of pulse power because of its extremely low on-voltage drop and simple gate drive circuit. However, under the condition that the system has a growing demand for switching devices with high withstand voltage levels, the withstand voltage level of a single device can no longer meet the needs of the system, so connecting devices in series to increase the withstand voltage level is a fast and economical solution. By analyzing the equivalent circuit of the gate, it is found that the reliability of the circuit can be improved by appropriately increasing the gate resistance without affecting the normal conduction of the device. Applying the principle of transformer isolation at the driving end can improve the synchronization of the gate signals. After simulation analysis of the dynamic equalization voltage of the series circuit, the method of paralleling the RCD absorption circuit to each device is obtained to eliminate the problem of excessive voltage across the device due to inconsistent parasitic parameters of the device. Finally, by analyzing the test results of the series circuit, a series circuit with simple circuit, high reliability, good voltage equalization, and high peak current is obtained.

Key words: MOS-controlled thyristor, pluse discharge, series circuit, dynamic average voltage, static average voltage

中图分类号:

TN386.1

张兴强，陈楠，陈万军. 一种基于CS-MCT串联的脉冲放电电路设计与实现[J]. 电子与封装, 2020, 20(7): 070305 .

ZHANG Xinqiang, CHEN Nan, CHEN Wanjun. Design and Implementation of a Pulse Discharge Circuit Based on CS-MCT Series[J]. Electronics & Packaging, 2020, 20(7): 070305 .

参考文献

[1] 任亚东，李世平，颜骥，等.半导体脉冲功率开关的最新进展[J].强激光与粒子束，2012,24(4):771-775.
[2] LI Xiaoang, LIU Xuandong, ZENG Fanhui, et al. Study on resistance and energy deposition of spark channel under the oscillatory current pulse[J]. IEEE Transactions on Plasma Science, 2014,42(9): 2259-2265.
[3] FAIR H D. Electromagnetic launch: a review of U.S. national program[J]. IEEE Transactions on Magnetics, 1997, 33(1): 502-512.
[4] ORESHKIN V I, LAVRINOVICH I V. Energy loss in spark gap switches[J]. Physics of Plasmas, 2014, 21(4): 043513-1-043513-8.
[5] BELODUBROVSKY R, MIRONOVA T, ERMOLINSKY V, et al. The method of increasing of pulp yield with kraft cooking[C]. 14th IEEE international pulsed power conference. Dallas, Texas, USA: IEEE, 2003: 1282-1285.
[6] GRABOWSKI C, DEGNAN J H, PARKER J V, et al. Parallel triggering and conduction of rail-gap switches in a high-current low-inductance crowbar switch[J]. IEEE Transactions on Plasma Science, 2016, 44(10): 1997-2012.
[7] 湛怡，夏连胜，王卫，等. 基于光导开关和平板线的固态脉冲功率技术[[J]. 太赫兹科学与电子信息学报，2014, 12(1): 32-36.
[8] 曾晗.大功率两电极气体火花开关的研究[[D]. 武汉: 华中科技大学，2012.
[9] SLENES K M , WINSOR P , SCHOLZ T , et al. Pulse power capability of high energy density capacitors based on a new dielectric material[J]. IEEE Transactions on Magnetics, 2001, 37(1): 324-327.
[10] CHEN Wanjun, LIU Chao, TANG Xuefeng, et al. High Peak Current MOS Gate-Triggered Thyristor with Fast Turn-On Characteristics for Solid-State Closing Switch Applications[J]. IEEE Electron Device Letter, 2016, 37(2): 205-208.
[11] CHEN Wanjun, LIU Chao, TANG Xuefeng, et al. Experimentally demonstrate a cathode short MOS-controlled thyristor(CS-MCT) for single or repetitive pulse applications[C].In:Power Semiconductor Devices and Ics(ISPSD), 2016 28th International Symposium on.IEEE, 2016: 311-314.
[12] CHEN Wanjun, SUN Ruize, XIAO Kun, et al. A behavioral model for MCT surge current analysis in pulse discharge[J]. Solid-State Electronics, 2014, 99: 31-37.
[13] 刘亚伟，陈万军. MOS栅控晶闸管在超高di/dt应用中的失效分析[J]. 电子与封装, 2018, 18(7): 45-48.
[14] 刘磊. IGBT串联均压技术的研究[D]. 南京：南京航空航天大学，2009.

中国半导体行业协会封装分会会刊

中国电子学会电子制造与封装技术分会会刊

一种基于CS-MCT串联的脉冲放电电路设计与实现

Design and Implementation of a Pulse Discharge Circuit Based on CS-MCT Series

RichHTML

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	程琳;罗佳敏;龚存昊;张有润;唐毅;门富媛;都小利. 10 kV SiC GTO器件特性研究^*[J]. 电子与封装, 2022, 22(3): 30102-.
[2]	袁榕蔚;刘超;陈万军. 基于导通延迟补偿的并联MOS栅控晶闸管均流方法研究[J]. 电子与封装, 2021, 21(7): 70403-.
[3]	周琪钧，田冕，刘超，陈万军. 亚阈电流对MOS栅控晶闸管dV/dt抗性的影响[J]. 电子与封装, 2020, 20(8): 80402-.
[4]	刘亚伟，陈万军. MOS栅控晶闸管在超高di/dt应用中的失效分析[J]. 电子与封装, 2018, 18(7): 45-48.